国产精品欧美在线,91久久久国产精品,天堂资源在线亚洲视频

商品詳情

武漢威格士軸向柱塞泵PVH131R13AF30B252000002001AB010A原裝進口

液壓泵流量問題

(1)吸入量不足。原因是吸油管路上的阻力過大或補油量不足。如泵的轉速過大，油箱中液面過低，進油管漏氣，濾油器堵塞等。

(2)泄漏量過大。原因是泵的間隙過大，密封不良造成。如配油盤被金屬碎片、鐵屑等劃傷，端面漏油;變量機構中的單向閥密封面配合不好，泵體和配油盤的支承面有砂眼或研痕等。可以通過檢查泵體內液壓油中混雜的異物判別泵被損壞的部位。

(3)傾斜盤傾角太小，泵的排量少，這需要調節變量活塞，增加斜盤傾角。

中位時排油量不為零

變量式軸向柱塞泵的斜盤傾角為零時稱為中位，此時泵的輸出流量應為零。但有時會出現中位偏離調整機構中點的現象，在中點時仍有流量輸出。其原因是控制器的位置偏離、松動或損傷，需要重新調零、緊固或更換。泵的角度維持力不夠、傾斜角耳軸磨損也會產生這種現象。

輸出流量波動

輸出流量波動與很多因素有關。對變量泵可以認為是變量機構的控制不佳造成，如異物進入變量機構，在控制活塞上劃出階痕、磨痕、傷痕等，造成控制活塞運動不穩定。由于放大器能量不足或零件損壞、含有彈簧的控制活塞的阻尼器效能差，都會造成控制活塞運動不穩定。流量不穩定又往往伴隨著壓力波動。這類故障一般要拆開液壓泵，更換受損零部件，加大阻尼，提高彈簧剛度和控制壓力等。

輸出壓力異常

泵的輸出壓力是由負載決定的，與輸入轉矩近似成正比。輸出壓力異常有兩種故障。

(1)輸出壓力過低

當泵在自吸狀態下，若進油管路漏氣或系統中液壓缸、單向閥、換向閥等有較大的泄漏，均會使壓力升不上去。這需要找出漏氣處，緊固、更換密封件，即可提高壓力。溢流閥有故障或調整壓力低，系統壓力也上不去，應重新調整壓力或檢修溢流閥。如果液壓泵的缸體與配流盤產生偏差造成大量泄漏，嚴重時，缸體可能破裂，則應重新研磨配合面或更換液壓泵。

(2)輸出壓力過高

若回路負載持續上升，泵的壓力也持續上升，當屬正常。若負載一定，泵的壓力超過負載所需壓力值，則應檢查泵以外的液壓元件，如方向閥、壓力閥、傳動裝置和回油管道。若壓力過高，應調整溢流閥。

振動和噪聲

振動和噪聲是同時出現的。它們不僅對機器的操作者造成危害，也對環境造成污染。

(1)機械振動和噪聲

如泵軸和電機軸不同心或頂死，旋轉軸的軸承、聯軸節損傷，彈性墊破損和裝配螺栓松動均會產生噪聲。對于高速運轉或傳輸大能量的泵，要定期檢查，記錄各部件的振幅、頻率和噪聲。如泵的轉動頻率與壓力閥的固有頻率相同時，將會引起共振，可改變泵的轉速以消除共振。

(2)管道內液流產生的噪聲

進油管道太細、進油濾油器通流能力過小或堵塞、進油管吸入空氣、油液豁度過高、油面過低吸油不足和高壓管道中產生液擊等，均會產生噪聲。因此，必須正確設計油箱，正確選擇濾油器、油管和方向閥。

液壓泵過熱

液壓泵過度發熱有兩個原因，一是機械摩擦生熱。由于運動表面處于干摩擦或半干摩擦狀態，運動部件相互摩擦生熱。二是液體摩擦生熱。高壓油通過各種縫隙泄漏到低壓腔，大量的液壓能損失轉為熱能。所以正確選擇運動部件之間的間隙、油箱容積和冷卻器，可以杜絕泵的過度發熱和油溫過高的現象。另外，回油過濾器堵塞造成回油背壓過高，也會引起油溫過高和泵體過熱。

漏油

柱塞泵漏油主要有以下原因:

(1)主軸油封損壞或軸有缺陷、劃痕;

(2)內部泄漏過大，造成油封處壓力增大，而將油封損傷或沖出;

(3)泄油管過細過長，使密封處漏油;

(4)泵的外接油管松動，管接頭損傷，密封墊老化或產生裂紋;

(5)變量調節機構螺栓松動，密封破損;

(6)鑄鐵泵殼有砂眼或焊接不良。

（威格士）新型號：（威格士）老型號：
PVH098L53AJ30B252000001AD200010A PVH98C2-LAF-3D-10-C25V-31-CD
PVH098L53AJ30B252000001AD2AA010A PVH98C2-LAF-3D-11-C25V-31-CD
PVH098L53AJ30E252004001AD1AA010A PVH98C2-LAF-3S-11-C25VT4-31
PVH098L52AJ30B192000AA1001AA010A PVH98C2-LF-2S-11-C19VB-31-CD
PVH098L52AJ30B252000001001AA010A PVH98C2-LF-2S-11-C25V-31-181
PVH098R53AJ30B252000001AD200010A PVH98C2-RAF-3D-10-C25V-31-CD
PVH098R53AJ30B252000001AD2AA010A PVH98C2-RAF-3D-11-C25V-31-CD
PVH098R52AJ30B252000001AJ1AA010A PVH98C2-RBF-2S-11-C25V-31-036
PVH098R51AJ30B252000001001AA010A PVH98C2-RF-1S-11-C25V-31
PVH098R52AJ30B192000AA1001AA010A PVH98C2-RF-2S-11-C19VB-31-CD
PVH098R02AJ70B202000001AD8AA010A PVH98C3-RAF-2D-11-C20V-31-036
PVH098R03AJ70B252000AA1AD1AA010A PVH98C3-RAF-3S-11-C25VB-31-CD
PVH098L13AJ30A250000001AD100010A PVH98C-LAF-13S-10-C25-31
PVH098L13AJ30B252000001AD100010A PVH98C-LAF-13S-10-C25V-31
PVH098L13AJ30B252000001AD1AA010A PVH98C-LAF-13S-11-C25V-31
PVH098L13AJ30E252004001AD1AA010A PVH98C-LAF-13S-11-C25VT4-31
PVH098L02AJ30B172000001AD200010A PVH98C-LAF-2D-10-C17V-31-036
PVH098L52AJ30B252000001AD200010A PVH98C-LAF-2D-10-C25V-31-080
PVH098L02AJ30B252000001AD2AA010A PVH98C-LAF-2D-11-C25V-31-036
PVH098L02AJ30A130000AG1AD100010A PVH98C-LAF-2S-10-C13-31-036
PVH098L02AJ30B172000001AD100010A PVH98C-LAF-2S-10-C17V-31-036
PVH098L02AJ30A200000001AD100010A PVH98C-LAF-2S-10-C20-31-036
PVH098L02AJ30B252000001AD100010A PVH98C-LAF-2S-10-C25V-31-036
PVH098L02AJ30B252000001AD1AM010A PVH98C-LAF-2S-10-C25V-31-119
PVH098L02AJ30B252000001AD1BG010A PVH98C-LAF-2S-10-C25V-31-160
PVH098L02AJ30B102000AG1AD1AA010A PVH98C-LAF-2S-11-C10V-31-036
PVH098L02AJ30A250000001AT1AA010A PVH98C-LAF-2S-11-C25-31-031
PVH098L02AJ30B252000001AD1AA010A PVH98C-LAF-2S-11-C25V-31-036
PVH098L02AJ30B252000001AD1AN010A PVH98C-LAF-2S-11-C25V-31-119
PVH098L03AJ30B282000001AD200010A PVH98C-LAF-3D-10-C28V-31
PVH098L03AJ30B252000001AD2AR010A PVH98C-LAF-3D-11-C25V-31-164
PVH098L03AJ30B252000001AD100010A PVH98C-LAF-3S-10-C25V-31
PVH098L03AJ30B252000001AD1AP010A PVH98C-LAF-3S-10-C25V-31-164
PVH098L03AJ30B282000001AD100010A PVH98C-LAF-3S-10-C28V-31
PVH098L03AJ30A250000001AD1AA010A PVH98C-LAF-3S-11-C25-31
PVH098L03AJ30E252015001AD1AA010A PVH98C-LAF-3S-11-C25VT15-31
PVH098L03AJ30E252004001AD1AA010A PVH98C-LAF-3S-11-C25VT4-31
PVH098L02AJ30A250000001AJ2AA010A PVH98C-LBF-2D-11-C25-31-CD
PVH098L02AJ30A250000001AJ100010A PVH98C-LBF-2S-10-C25-31-036
PVH098L02AJ30B252000001AB100010A PVH98C-LBF-2S-10-C25V-31-229

PVH098L02AJ30B252000001AJ1AA010A PVH98C-LBF-2S-11-C25V-31-036
PVH098L03AJ30B172000001AJ2AA010A PVH98C-LBF-3D-11-C17V-31
PVH098L03AJ30B212000001AJ1BG010A PVH98C-LBF-3S-10-C21V-31-189
PVH098L03AJ30A250000001AJ1AA010A PVH98C-LBF-3S-11-C25-31
PVH098L03AJ30B252000001AJ1AA010A PVH98C-LBF-3S-11-C25V-31-CD
PVH098L02AJ30B182000001AM2AA010A PVH98C-LCF-2D-11-C18V-31-036
PVH098L02AJ30B252000001AA100010A PVH98C-LCF-2S-10-C25V-31-CD
PVH098L03AJ30B212000001AM2BG010A PVH98C-LCF-3D-10-C21V-31-189
PVH098L03AJ30A250000001AM2AA010A PVH98C-LCF-3D-11-C25-31-CD
PVH098L03AJ30B252000001AM100010A PVH98C-LCF-3S-10-C25V-31
PVH098L05AJ30B252000001AM1AA010A PVH98C-LCF-5S-11-C25V-31
PVH098L01AJ30A25000000100100010A PVH98C-LF-1S-10-C25-31
PVH098L01AJ30B25200000100100010A PVH98C-LF-1S-10-C25V-31
PVH098L01AJ30A07000000100100010A PVH98C-LF-1S-10-CM7-31
PVH098L01AJ30B252000001001AA010A PVH98C-LF-1S-11-C25V-31
PVH098L01AJ30B252000AA1001AA010A PVH98C-LF-1S-11-C25VB-31
PVH098L02AJ30B20200000100200010A PVH98C-LF-2D-10-C20V-31
PVH098L02AJ30B182000001002AA010A PVH98C-LF-2D-11-C18V-31
PVH098L02AJ30A250000001002AA010A PVH98C-LF-2D-11-C25-31
PVH098L02AJ30A100000AG100100010A PVH98C-LF-2S-10-C10-31
PVH098L02AJ30B102000AG100100010A PVH98C-LF-2S-10-C10V-31
PVH098L52AJ30B24200000100100010A PVH98C-LF-2S-10-C24V-31-027
PVH098L02AJ30A25000000100100010A PVH98C-LF-2S-10-C25-31
PVH098L02AJ30B25200000100100010A PVH98C-LF-2S-10-C25V-31
PVH098L02AJ30B252000001001AM010A PVH98C-LF-2S-10-C25V-31-118
PVH098L02AJ30B252000001001BG010A PVH98C-LF-2S-10-C25V-31-159
PVH098L02AJ30B252000001001AP010A PVH98C-LF-2S-10-C25V-31-164
PVH098L02AJ30B252000AL1001AP010A PVH98C-LF-2S-10-C25V-31-208
PVH098L02AJ30B13200000100100010A PVH98C-LF-2S-10-CM13V-31
PVH098L02AJ30K25000000100100010A PVH98C-LF-2S-10-EDC25-10
PVH098L02AJ30A100000AG1001AA010A PVH98C-LF-2S-11-C10-31
PVH098L02AJ30B102000AG1001AA010A PVH98C-LF-2S-11-C10V-31
PVH098L02AJ30A130000AG1001AA010A PVH98C-LF-2S-11-C13-31
PVH098L02AD30F262021001001AA010A PVH98C-LM-2S-11-C26VT21S-31
PVH098L01AJ30A25000000200100010A PVH98C-LSF-1S-10-C25-31
PVH098L51AJ30A25000000200100010A PVH98C-LSF-1S-10-C25-31-027
PVH098L01AJ30A070000002001AA010A PVH98C-LSF-1S-11-CM7-31
PVH098L02AJ30A25000000200100010A PVH98C-LSF-2S-10-C25-31
PVH098L02AJ30B25200000200100010A PVH98C-LSF-2S-10-C25V-31
PVH098R13AJ30B211700001AD100010A PVH98C-RAF-13S-10-C21V17-31
PVH098R13AJ30B212000AA1AD100030A PVH98C-RAF-13S-10-C21V20B-31-0B
PVH098R13AJ30B212000001AT100010A PVH98C-RAF-13S-10-C21V-31-031
PVH098R13AJ30A250000001AD100010A PVH98C-RAF-13S-10-C25-31
PVH098R13AJ30B252000001AD100010A PVH98C-RAF-13S-10-C25V-31
PVH098R13AJ30A070000001AD100010A PVH98C-RAF-13S-10-CM7-31
PVH098R13AJ30A250000001AD1AA010A PVH98C-RAF-13S-11-C25-31
PVH098R13AJ30B252000001AD1AA010A PVH98C-RAF-13S-11-C25V-31
PVH098R13AJ30E252004001AD1AA010A PVH98C-RAF-13S-11-C25VT4-31
PVH098R02AJ30B182000001AD200010A PVH98C-RAF-2D-10-C18V-31-036
PVH098R02AJ30B202000001AD200010A PVH98C-RAF-2D-10-C20V-31-036
PVH098R02AJ30B192000001AD2AA010A PVH98C-RAF-2D-11-C19V-31-036
PVH098R02AJ30A250000001AD2AA010A PVH98C-RAF-2D-11-C25-31-036
PVH098R02AJ30B252000001AD100010A PVH98C-RAF-2S-10-C25V-31-036

PVH098R02AJ30B172000001AD1AA010A PVH98C-RAF-2S-11-C17V-31-036
PVH098R02AJ30A250000001AD1AA010A PVH98C-RAF-2S-11-C25-31-036
PVH098R02AJ30B252000001AD1AA010A PVH98C-RAF-2S-11-C25V-31-036
PVH098R02AJ30B481300AH1AD1AA010A PVH98C-RAF-2S-11-C275V13-31-109
PVH098R03AJ30B252000AL1AD8AP010A PVH98C-RAF-3D-10-C25V-31-208
PVH098R03AJ30B182000001AD2AA010A PVH98C-RAF-3D-11-C18V-31
PVH098R03AJ30A250000001AD2AA010A PVH98C-RAF-3D-11-C25-31
PVH098R03AJ30A250000001AD100010A PVH98C-RAF-3S-10-C25-31
PVH098R03AJ70A250000001AD100010A PVH98C-RAF-3S-10-C25-31-057
PVH098R03AJ30B252000001AD100010A PVH98C-RAF-3S-10-C25V-31
PVH098R03AJ30B252000001AD1AP010A PVH98C-RAF-3S-10-C25V-31-164
PVH098R03AJ30B252000AL1AD1AP010A PVH98C-RAF-3S-10-C25V-31-208
PVH098R03AJ30B252000001AD1AA010A PVH98C-RAF-3S-11-C25V-31
PVH098R03AJ30E252008001AD1AA010A PVH98C-RAF-3S-11-C25VT8-31
PVH098R13AJ30B252000001AJ1AA010A PVH98C-RBF-13S-11-C25V-31
PVH098R02AJ30A250000001AJ2AA010A PVH98C-RBF-2D-11-C25-31-036
PVH098R02AJ30E252008001AJ1AA010A PVH98C-RBF-2S-11-C25VT8-31-CD-